Volkswagen Owners Club Forum banner
injection

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-18 of 156 Results
Advanced
  1. Classic VW Beetle / Bug Forum
    RPM stays high while shifting between gears. If in neutral and the accelerator is depressed momentarily the RPM stays high for about 5 seconds then goes back to idle RPM. Any ideas please.
  2. 1975 - 1984 VW Rabbit General Forum
    I have a good running diesel engine (1982) but the injection pump is leaking now where the cold start valve cable connection mounts. Can this seal be replaced without taking the pump apart? I have a complete rebuild kit for an injection pump, but I'd just like to replace the cold start valve...
  3. Private Party 'For Sale' Classifieds
    FS Giles modified Bosch VE Injection Pump for VW 1.6l or 1.9l diesel engine. The model # is 068 130 107 AG. This ip was installed on a 1.9l 1Y na engine that I've since turboed, which necessitated an upgraded ip from Giles. Asking $500 plus free shipping (lower forty eight states only)
  4. Polo Owners Club
    My cam belt snapped,,, happily it was just being turned over to examine the belt,, top cover was off Anyway my problem,,,, since cam belt came off I never got a chance to mark anything. No problem with the cam shaft position but I can’t find any markings on the crank ( pulley 0ff ) and also...
  5. Classic VW Beetle / Bug Forum
    I'm trying to identify and replace what I believe is the voltage regulator on my 1977 Fuel Injection Beetle. Unfortunately, nothing I see on the internet matches up with my part. Can someone confirm what this is and if it's unusual or if there's a newer version that will work? Thanks.
  6. 1975 - 1984 VW Rabbit General Forum
    I had a voltage regulator fail and overcharged the system for maybe a day or two. Now I can't get my truck started. What parts of the ignition system could have been damaged by this? Coil, ignition control module (ICM), Hall sender, plugs or wires (coil to distributor wire)? I'm hoping none of...
  7. Air-cooled Owners Club
    Looking at buying a 79 Convertible with 61xxx original miles. From the pics it looks great. However, it still has the original fuel injection system on it. My question is this. How reliable is the system. I've heard some negatives about it. The guy has agreed to drive 75 miles to meet me...
  8. MK1 Rabbit Mods / DIYs
    I have an 84 MK1 Cabriolet with an ABA swap. It has been running well till this morning. It turns over fine, it tried once to start but then nothing. Just cranks over. Recently my wife ran it out of fuel, I am wondering if maybe there is something on the fuel line. I am not sure where the...
  9. GTI MK1 / 1983-1984
    I have a 1984 rabbit gti, and the injector tubes are shot. They are cracked and torn in areas, and seals they sat on were crumbling. I ordered a couple new ones from napa, but they were not the same and came with no seals. I was wondering if anyone on here knew anything about those injector...
  10. Golf MK4 / 1999-2002
    Hi guys, my 1.8t is being a nightmare again, it struggles to start, when it drives there is no boost (Boost gauge read vacuum but no boost at all) even if you really rev it theres no boost, ive changed pipes near inlet manifold incase of leaks, I did notice one of the pipes going into the rocker...
  11. 1975 - 1984 VW Rabbit General Forum
    Hi. I was just wondering what might the cause and solutionfor gas leaking from the injection pump in my 81 rabbit diesel.
  12. 1975 - 1984 VW Rabbit General Forum
    1980 VW Diesel 5 speed rebuilt injection pump Gas gage flakey, but think i had gas Driving down road engine quit running coasted into gas station filled up only too 4 gal started up OK drove about 200' and engine quit again, coasted off road car would not start, no fuel in inlet fuel line...
  13. Golf Owners Club
    I have a golf 18 injection which runs really rough when the petrol gets low , does anyone have any ideas ,as to what is wrong with it many thanks nikki
  14. Volkswagen Technical Discussions - General
    I want all my content removed!
  15. Beetle Owners Club
    The Potentiometer on the Intake Air Sensor of my ex-USA Super Beetle has failed. (Bosch part no 0280200006). Bosch no longer do it as a service replacement part, anyone know someone who can rebuild/overhaul the unit?
  16. 1975 - 1984 VW Rabbit General Forum
    I have a 1983 vw rabbit. 1.7 fuel injection was swapped in. (i believe 1.7l) but it is fuel injected. start the car up and it runs for a little while, then dies. starts back up and does it again. it feels like there is a clog or something. im a newbie and need help with this!
  17. 1975 - 1984 VW Rabbit General Forum
    I love vws. Have owned 3 now. Just bought this 83 yesterday and I'm already having problems. All day today it's had a stuttering issue. It doesn't occur over 30 mph. When it happens the Rpms go up and down and then the car wants to die if I don't push on the gas. But sometimes it just dies. I...
  18. 1975 - 1984 VW Rabbit General Forum
    My 82 rabbit has an 85 gti motor in it and I have had nothing but problems with the stupid fuel injection so I got the weber carb conversation kit. My question is do I need to change the distributor that is on it or can I work with what I have and how? I finished the install and now have no...
1-18 of 156 Results
Top