Volkswagen Owners Club Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-18 of 500 Results
  1. Golf MK2 / 1983-1992
    Hi All, i parked my VW golf out for a year unstarted and now it wont start I added 911 deisel de geller in stnk and in fuel filter (+frsh deisel ) no start I also dont hear a fuel pump when in the run position should I ? Also when i cowboy it and pull off the hose from fuel filter to injector...
  2. Jetta New To Forum / Frequently Asked Questions
    I have a 2001 Jetta TDI which developed a transmission fluid leak. Having pulled the transmission I can see that the pump bushing is worn and needs to be replaced. I have searched the internet to find a replacement bushing and am alignment tool without success. Is there anyone out there who...
  3. Volkswagen Technical Discussions - General
    Hello, the video shows how to change the servo pump on a Passat 35i. The approach is the same for many comparable vehicles with hydraulic power steering. These instructions may help there too. After the change, the system still has to be bleeded, this procedure is also shown in detail...
  4. 1975 - 1984 VW Rabbit General Forum
    What is the rated GPM requirements of the IP in the 1.6 NA? I'm looking to do a 2-tank system in the near future on the 80 Caddy and POSSIBLY the '84 HB I as well. Need a couple 3-way solenoid valves to make it work and my selection is currently set on 2 different sizes. One varies between...
  5. Touareg Owners Club
    I am currently stumped on a 2005 VW Touareg 3.2 engine code G where the p/s fuel pump loses power after approximately 30 seconds of running. Fuel pressure drops until vehicle dies. Starts right back up and fuel pump gets power again , but loses it after 30 seconds and the cycle repeats itself...
  6. Volkswagen Tiguan Forum
    Hello. I just purchased used Tiguan. After I left my garage I saw oils on the floor. Oil comes from front passenger side about 4 inches from right front tire. Oil color is dark brown/light brown. I have appointments with service in few days but I am trying to learn VW system too I just wish to...
  7. 1975 - 1984 VW Rabbit General Forum
    So I've recently came into possession of a 79 rabbit rally edition with the 1.5l diesel engine. I am having trouble getting it to stay running let alone starting. I've replaced the battery, starter, alternator, glow plugs, fuel pump and wiring.. could cleaning the Injectors help? Willing to...
  8. 1975 - 1984 VW Rabbit General Forum
    I have a 1988 Caddy diesel pickup that was built in Germany for the German Red Cross. Has 10,000 orig. km but my mechanic says the injector pump is bad. Any idea where I may find one, what differences are, or if anyone rebuilds them? they are having no luck finding one, but it has a german vin...
  9. VW Touareg Technical
    Do I need a turbo if I just had my brake vacuum pump replaced
  10. Touareg Owners Club
    I have a VW Touareg just had the Brake vacuum pump replaced and the garage now say they need to replace the turbo any help
  11. 1975 - 1984 VW Rabbit General Forum
    Hey all, looking for any advice on my issues here. I've got an 81 diesel caddy. Currently overheating and I'm not sure where to look next. It's always done fine, even when I lived in Arizona (I'm in SE Ohio now). Last summer on a trip to Pittsburg it started overheating climbing all the hills in...
  12. Jetta / Bora MK5 / 2005–2010
    hi . i seem to be having an issue with my jetta mk5. 1.9tdi. whilst driving the engine cut out and now wont start at all. checked all fuses and relays. all working. checked fuel line. all clear. checked diesel pump. 100%. now when i try to start i get a "oil presure low engine off" warning. what...
  13. 1975 - 1984 VW Rabbit General Forum
    Ok so I've been driving a 1981 vw rabbit caddy for about 2 months now. The engine sat for over a year but started right up and has been fine till a few days ago. I was driving down the highway and it died in gear some how and felt like it bound up. My first thought was oil or fuel. But now I'm...
  14. TIGUAN OWNERS CLUB
    I have changed the water pump twice before on the Tiguan and cannot remember the torques specs for the 5 bolts to the block. Have the sequence but cannot find where I have written it down. I have found online in the audi workshop manual the spec being 9 nm (6.63 ft. lbs) which seems low to me...
  15. 1975 - 1984 VW Rabbit General Forum
    I have a good running diesel engine (1982) but the injection pump is leaking now where the cold start valve cable connection mounts. Can this seal be replaced without taking the pump apart? I have a complete rebuild kit for an injection pump, but I'd just like to replace the cold start valve...
  16. Volkswagen Tiguan Forum
    Looks like my water pump has gone out...mechanic researching (non vw guy...my mechanic), 96k miles. Since they have to rip into it to potentially replace it is there anything I should also do during this maintenance w/ the mileage on the vehicle? Also, any ball park on $$$$$ of something like...
  17. Private Party 'For Sale' Classifieds
    FS Giles modified Bosch VE Injection Pump for VW 1.6l or 1.9l diesel engine. The model # is 068 130 107 AG. This ip was installed on a 1.9l 1Y na engine that I've since turboed, which necessitated an upgraded ip from Giles. Asking $500 plus free shipping (lower forty eight states only)
  18. MK1 Rabbit Engine
    I have a Giles (Performance Diesel) ip that I would like to list in the classifieds but don't know the correct procedure. Thanks, Carsonic
1-18 of 500 Results
Top